Operating Instructions and Parts Manual Electric Hoist Models SS-1C, SS-3C WALTER MEIER (Manufacturing) Inc. 427 New Sanford Road LaVergne, Ten
10Inspecting Hoist Motion 1. Before closing the circuit breaker and testing the hoist, check that wiring has been complete. If the hoist cannot be o
11 Figure 8 Figure 9 7. Remove the screw and washer holding the end chain to the hoist (Figure 10). Mount the bracket of the chain container in tha
12durability. Over a period of time, the chain may need to be replaced. For your own safety, use factory replacement chain only. Use of other than fa
139. Lower load at destination. If both UP and DOWN commands must be used during lowering, pause for a moment between each reversal of load directio
14Replacing Load Chain Over time, the load chain will wear or elongate. This can cause damage to the hoist, breakage, or non-engagement of the load s
Figure 18Dual/Multiple Fall Chain Hoists The link on the load side end must be a vertical link. If it is a horizontal link, the chain will have a t
1612. It is recommended that the first few lifts be limited to no more than 25-50% of the rated load. Inspect chain for twist before placing hoist in
17Inspection and Maintenance All repairs and adjustments are to be performed by trained and experienced personnel using procedures that are approved
18Inspection Procedures: Allowable Limits Load Chain Carefully inspect the entire load chain. Measure five consecutive links with calipers in the man
19Brake Friction Pad See Figure 23. Before suspecting or replacing the brake friction pad, make sure the brake and the safety clutch have both been a
2 Warranty and Service Walter Meier (Manufacturing) Inc., warrants every product it sells. If one of our tools needs service or repair, one of our Au
20Troubleshooting Trouble Probable Cause Remedy Motor will not run. No incoming power, or low voltage. Check hoist connections to power source. If l
21Replacement Parts Replacement parts are listed on the following pages. To order parts or reach our service department, call 1-800-274-6848 Monday t
22Control Pendant Assembly Index No. Part No. Description Size Qty 104 ... 1/2SS-3C-104...Pushbutton Control (1 and 3 Phase, Single
231/2-Ton, 1-Ton and 2-Ton Chain Hoists
24Parts List: 1/2-Ton Chain Hoist Index No. Part No. Description Size Qty 1 ... 1/2SS-3C-001...Motor Stay Bolt ...
25Index No. Part No. Description Size Qty 41-3 ... 1/2SS-1C-04103 ...Friction Pad for 1 Phase ...
26 Index No. Part No. Description Size Qty 83 ... TS-1550061 ...Plain Was her ...8
27Parts List: 1-Ton and 2-Ton Chain Hoists Index No. Part No. Description Size Qty 1 ... 1SS-3C-001 ...Motor Stay Bolt ...
28Index No. Part No. Description Size Qty 41-3 ... 1SS-1C-04103 ...Friction Pad for 1 Phase ...
29Index No. Part No. Description Size Qty 80-1 ... 1SS-3C-08001 ...Phillips Pan Head Machine Screw...M6x16...
3 Table of Contents Warranty and Service ...
303-Ton Chain Hoist
31Parts List: 3-Ton Chain Hoist Index No. Part No. Description Size Qty 1 ... 1SS-3C-001 ...Motor Stay Bolt ...
32Index No. Part No. Description Size Qty 41-3 ... 1SS-1C-04103 ...Friction Pad for 1 Phase ...
33 Index No. Part No. Description Size Qty 81 ... 1SS-3C-076 ...Retainer Ring ...
345-Ton Chain Hoist
35Parts List: 5-Ton Chain Hoist Index No. Part No. Description Size Qty 1 ... 1SS-3C-001 ...Motor Stay Bolt ...
36Index No. Part No. Description Size Qty 41-3 ... 1SS-1C-04103 ...Friction Pad for 1 Phase ...
37Index No. Part No. Description Size Qty 82 ... 1SS-3C-077 ...Chain Stop ...
38Hook Assemblies (1/2-Ton, 1-Ton and 2-Ton)
39Parts List: Hook Assemblies (1/2-Ton only) Index No. Part No. Description Size Qty 17 ... 1/2SS-3C-017...Top Hook Assembly for
4 Warning 1. Read and understand the entire owner’s manual before attempting assembly or operation. 2. Read and understand the warnings posted on
40Parts List: Hook Assemblies (2-Ton only) Exploded view on page 38. Index No. Part No. Description Size Qty 17 ... 2SS-3C-017 ...
41Hook Assemblies (3-Ton only)
42Parts List: Hook Assemblies (3-Ton only) Exploded view on page 41. Index No. Part No. Description Size Qty 17 ... 3SS-3C-017 ...
43Parts List: Hook Assemblies (5-Ton only)
44Parts List: Hook Assemblies (5-Ton only) Exploded view on page 43. Index No. Part No. Description Size Qty 17 ... 5SS-3C-017 ...
45Electrical Connections: Single Phase Only
46Electrical Connections: 3-Phase, Single Speed Only
48 WALTER MEIER (Manufacturing) Inc. 427 New Sanford Road LaVergne, Tennessee 37086 Phone: 800-274-6848 www.waltermeier.com
5 Familiarize yourself with the following safety notices used in this manual: This means that if precautions are not heeded, it may result in minor
6 Specifications – Single Phase Available in 10’, 15’ and 20’ lifts. Model Rated Cap’y (ton) Hoisting Speed (f/min.) Headroom (in.) Motor Duty Cycl
7 Specifications – Three Phase Available in 10’, 15’ and 20’ lifts. Model Rated Cap’y (ton) Hoisting Speed (f/min.) Head-room (in.) Motor Duty Cyc
8 Unpacking Open shipping container and check for shipping damage. Report any damage immediately to your distributor and shipping agent. Do not disca
9 2. Open the connector caps on the two female connectors (Figure 2) and two male plugs (Figure 3). 3. Check orientation of notches on the female c
Comments to this Manuals